Productsph modifiers for sulfide copper ores flotation

BF Flotation Cell

BF flotation cell has two types: type I and type II. Type I is improved as suction cell referring to model SF; type II is improved as direct flow cell referring to model JJF.

more+

Cyclone Unit

Each feeding inlet of Xinhai cyclone unit is installed knife gate valve independently developed by Xinhai. This valve with small dimension reduces the diameter of cyclone unit.

more+

Hydraulic Cone Crusher

The supports at both ends of cone crusher main shaft, scientific design of crushing chamber, double insurance control of hydraulic and lubricating system.

more+

Overflow Type Ball Mill

Wet type overflow ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance, long service life and convenient maintenance

more+

Grid Type Ball Mill

Wet type grid ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance design, long service life and convenient maintenance.

more+

Round Vibrating Screen(YA)

Ring groove rivets connection, plate type screen box, advanced structure, strong and durable Vibration exciter with eccentric shaft and eccentric block, high screening efficiency, large capacity

more+

Jaw Crusher

Xinhai improves the traditional specification of crushing chamber by adopting high speed swing jaw and cambered jaw plate.

more+

Hammer Crusher

High-speed hammer impacts materials to crush materials. There are two ways of crushing (Wet and dry)

more+

Jig

The cone slide valve is adopted; the failure rate is reduced by 80%; low energy consumption;the separation of different material, improvement of the processing capacity by more than 35%.

more+

Energy Saving Ball Mill

Cylindrical energy saving grid ball mill is lined grooved ring plate which increases the contact surface of ball and ore and strengthens the grinding.

more+

Cylinder Energy-Saving Overflow Ball Mill

20-30%. Rolling bearings replace slipping bearings to reduce friction; easy to start; energy saving 20-30%

more+

SF Flotation Cell

Both sides of the impeller with back rake blades ensures double circulating of slurry inside the flotation tank. Forward type tank, small dead end, fast foam movement

more+

Flotation of Sulphide Ores - HZL Experience - [email protected]

Sulphide ores are major sources of base metals like Copper,. Lead, Zinc, Nickel, Cobalt etc. . Frother, Activator, Depressants, pH modifier. Amongst above,.

more+

PDF A Review of the Flotation of Copper Minerals - ResearchGate

Jul 21, 2017 as the sulphide ore is simpler to recover by conventional flotation procedures .. Modifiers can be classed as activators, depressants and pH.

more+

Investigation of Flotation Parameters for Copper Recovery from

Feb 22, 2012 Effect of particle size, slurry pH, flotation time, collector type, collector In the mineral industry, many copper and iron sulfide ores such as covellite .. of pH and redox potential regulatorsmodifiers was 4 and 450mV SHE.

more+

Sulfide minerals - an overview ScienceDirect Topics

The most common modifier in water–ore slurry is the OH− ion hydroxyl ion. Between pH 5 and pH 7.5 neutral slurry, CuFeS2 and PbS float while FeS2 is Copper sulfide minerals require the use of acid and an oxidizing agent to break

more+

Selective flotation of enargite from copper sulphides in complex ore

The study of the floatability of non-sulphide gangue minerals in the flotation of the HAS and the LAS Figure 2-6, Eh-pH diagram for the copperwater a, arsenicwater b, and sulphurwater c The interaction of pH modifiers with.

more+

Electrochemical Flotation Separation of Sulphide Minerals

minerals modified by different potential modifiers or pH modifiers may copper sulphide minerals and the flotation of lead-zinc-iron sulphide minerals.

more+

Flotation of Nickel-Copper Sulphide Ore - 911 Metallurgist

the flotation recovery of Ni, Cu and Co from a nickel-copper sulphide ore. analytical grade sulphuric acid and sodium hydroxide were used as pH modifiers.

more+

an investigation of copper recovery from a sulphide oxide ore with a

Aug 22, 2009 The flotation of a natural porphyry copper ore with bornite and malachite Figure 2.7- The effect of pH on potassium amyl xanthate uptake on Ammonium sulphide, NH42S , is a promising modifier because of its

more+

The Effect of Seaweed Glue in the Separation of Copper - MDPI

Jan 25, 2018 Copper–Molybdenum Sulphide Ore by Flotation the optimal reagent schedule: pH 4, depressant seaweed glue 197 mgL, collector amyl xanthate of Sodium Silicate as pH Modifier and Depressant in the Froth Flotation.

more+

Flotation Behavior of Complex Sulfide Ores in the Presence of

May 14, 2017 In sulfide mineral flotation, Polymers have been used as potential candidates sodium hydroxide Fisher scientific, USA were used as pH modifiers. Other notable elements are copper and iron with 0.7% and 2.27% of the

more+

Froth Flotation - Department of Chemical Engineering

separating sulfide minerals from silica gangue and from other sulfide minerals; separating potassium Table 1: Graderecovery performance of a hypothetical copper ore flotation process. .. The simplest modifiers are pH control chemicals.

more+

Sulphide Minerals: Surface Oxidation and Selectivity in - DiVA portal

flotation of a given sulphide mineral from other sulphides have always been experimental conditions have been explained by Eh–pH diagrams of these Chalcopyrite oxidizes to copper, ferric sulfates and iron oxide Steger & Desjardins. 1978. .. 150 ml capacity and conditioned with pH modifier, collector and frother.

more+

Froth flotation - Wikipedia

Froth flotation is a process for selectively separating hydrophobic materials from hydrophilic. . By 1991, the average grade of copper ore mined in the US had fallen to only 0.6 . Common collectors used in flotation are anionic sulfur ligands, which have a . Anionic modifiers include phosphates, silicates, and carbonates.

more+

Greening Chilean copper mining operations through industrial

Rougher flotation of copper sulphide ores using biosolids e from wastewater . and modifiers in froth flotation is increasing because higher amounts of .. the pH at 10, and 12 gt of diesel oil and 38 gt of the main collector were added.

more+

COPPER Copper production

Beneficiation by froth flotation of ore to give copper concentrate. Optional partial Additionally, modifiers like hydroxyl ions pH adjustment are used to select different sulfide minerals, for example, chalcopyrite and pyrite. Alcohols are used to

more+

optimisation of the froth flotation process of chingola refractory ores

refractory oxides and sulphide copper minerals with an average grade of certain minerals hydrophilic and pH modifiers regulate the ionic composition by

more+

nickel and cobalt ores: flotation - Semantic Scholar

Problems Associated with Sulfide Mineral Flotation. The main problem Flotation Practice in Nickel Sulfide. Deposits a highly alkaline pH with cyanide as depressant and using thiols like contain very low grades of nickel 0.6% and copper. 0.04}0.4%. . employing CaClO2, as modifier of potential, and. Ca2# ions.

more+

Application of Aeration to Complex Sulphide Ore and its Effects on

ABSTRACT: Clastic ore is one of the complex sulphide ores found in the Çayeli In order to improve copper concentrate quality, a decision was made to try Flotation collectors, modifiers and grinding Effect of Aeration pH on Metallurgy.

more+

MODIFIED TITANIUM WHITE FROM MINERAL PROCESSING

Key words: arsenic, non-toxic depressants, sulphide minerals, flotation lead-zinc ores, c bulk flotation of copper-lead-zinc minerals followed by a selective well with aerophine and mercaptan type of collectors at a pH value between 8 tors and modifiers to adjust surface properties Finkelstein, 1997; Yamamoto, 1980;.

more+

Investigation of effective parameters for molybdenite recovery from

Nov 10, 2013 COPPER ORES IN INDUSTRIAL FLOTATION CIRCUIT produces a bulk copper sulphide molybdenum sulphide concentrate. The second In many plants, lime is employed as a pH modifier as well as for the depression of.

more+

Dispersion effect on a lead–zinc sulphide ore flotation - CiteSeerX

Jan 31, 2009 The zinc flotation tests were carried out at pH . a sulphide copper ore. .. sive sodium carbonate as pH modifier in the industrial circuit.

more+

Selective flotation of sulphides from a gold mining operation - Cetem

from the flotation process of sulphide gold ore of mine Morro do Ouro. Chemical analysis of . The pH for the Rougher steps of Cu and Pb was 9.8 and the test conditions as follows: collector . sphalerite has already been activated with copper sulphate. Figure 5: . modifiers in complex sulfide flotation with DTPI. In: Woods

more+

Surface and chemical properties of chlorite in relation to its flotation

Chlorite depressants used in oxide and sulphide flotation are typical of those schemes collectors, modifiers and pH values for this aluminosilicate which .. the separation of copper sulphide minerals from quartz and chlorite gangue with a

more+

The behaviour of minerals in sulphide flotation processes - SAIMM

D. J. McKEE*, Ph.D., and . flotation rates of valuable sulphides and gangue min- erals in sulphide ores have been in- ing a variety of copper and lead-zinc.

more+

Study of Flotation Parameters for Copper Recovery from Tennantite

Keywords: Refractory Copper-pyrite Ores, Flotation, Tennantite, Arsenic, Recovery. 1.Introduction . Lime is normally used as a pH modifier in sulphide flotation.

more+

Minerals Engineering Conferences - Flotation 17

Performance characterisation of new frothers for sulphide mineral flotation Selective depression of pyrite using biopolymers in the flotation of copper sulphide minerals . Development of fatty acid modifier for beneficiation of the igneous apatite ores of Kovdor deposit Flotation of REE-minerals from fluorite by pH-shift

more+

recovery of copper from oxide copper ore by flotation and - METU

Dec 2, 2014 dosage of collectors, pH, and dosage of activator Na2S were examined. Results of Keywords: Copper Minerals, Flotation, Agitating Leaching used as frother, and ammonium sulphate NH42SO4 was used as modifier.

more+

AN ALKALINE GLYCINE-BASED PROCESS FOR COPPER

Milling and flotation often becomes uneconomic if the copper grades become alkaline pH 7-12 leaching of chalcopyrite offers a technology that can be applied to heap leaching, in-situ Chalcopyrite is a copper iron sulfide mineral refractory to conventional leach processes at room . No extraction modifiers were used.

more+

A study of the flotation characteristics of a complex copper ore

copper ore comprising sulphide and oxide minerals with a view to achieving an optimal flotation mineral-collector interaction is dependent pH modifiers.

more+

Silver ores - Danafloat

Often these minerals float with the base metals such as copper and lead sulphides or are Use of soda ash for elevating pH is suggested as an alternative pH modifier. When silver is associated with metal sulphide minerals, normal flotation

more+

Taguchi optimization: Case study of gold recovery - AIP Publishing

followed by the Potassium amyl xanthate concentration, pH and pine oil tailing contains valuable minerals such as gold, copper, and titanium that can be further recovered. process which is effective to increase the gold concentration in sulfide ores 1,2. Froth flotation process uses collector, frothers and modifiers to effect

more+

A review of the fundamental studies of the copper activation - NCBI

Sep 9, 2008 activation mechanisms for selective flotation of the sulfide minerals, Factors such as copper concentration, activation time, pH, surface

more+

EP0116616B1 - Process for the selective separation of base metal

Process for the separation of ore components by flotation comprising: grinding has been devoted to sulfide flotation in the absence of pH modifiers, i.e., at a natural The sample tested involved extremely pure copperzinc sulfide from high

more+

Progress in mineral processing technology of copper mine 2017

Jan 11, 2017 The beneficiation process changes flotation of copper sulfide ore using lime as a modifier, pyrite content is low pH value is 8~9, pyrite is high

more+

Froth flotation of Aljustrel sulphide complex ore - DOIs

May 17, 2016 Abstract: Froth flotation of copper-zinc-lead ores is a complex process depressants and pH regulators, equipment cell design, agitation,

more+

Tannins: the organic depressants alternative in selective flotation of

disseminated copper ore was tested considering different pH values and modifiers, and different levels of . is always present in sulphide flotation pulps and is known to form insoluble The pH modifier selected was sodium carbonate. As a.

more+

PRE Post:studies of the impact flotation process
NEXT Post:quartzite crushed stone for patio

1993-2018 Xinhai Machine . All rights reserved | Design by Xinhai